1999-2006 TIGER FAULTS AND WEAKNESSES
Unlike the kool-aid drinkers of other brands, I am fully willing to post the problems inherent to my favorite bike. Every single model of motorcycle ever made has had its idiosyncrasies. To deny that is foolishness. I am not a salesman trying to get a sales commission by talking people into buying a Tiger, nor am I suffering from low self-esteem, wanting others to stroke my ego by buying the same bike I did.
'99-'06 Tigers (Girlies) are as popular now as when they were still in production, and many people come to these forums to learn about these bikes, as they hash out the Goods-and-Bads of various bikes on their wish list. I believe in being honest and forthright with folks, so when somebody breezes in here wanting to know 'What can go wrong with a Girly Tiger?', they will be able to rationally weigh these points against the points of other bikes and make an educated decision once they're ready to buy.
The fact that hardly any of these possible problems are actually encountered by the typical Tiger owner speaks volumes about the sound design and inherent reliability of the bike...
Fuel gauges may be inaccurate and have been known to malfunction altogether, due to quirky sending units. The newer replacement sending units are better than the older ones.
1999-2003 Tigers came from the factory with all-plastic fuel line fittings at the tank, and are known to split, causing gasoline leaks. This was the subject of a factory recall in 2003. 2004 models have improved (partially metal) fittings. All-metal fittings can be had from TeamTriumph... http://www.triumph1.com/tiger.htm (http://www.triumph1.com/tiger.htm) . These items are not needed for (and will not fit) 2005-06 models, as they have a slightly different fuel system.
Gauge illumination is poor in twilight conditions due to white gauge faces and green illumination. Full daylight or full darkness is just fine.
Speedometer sending units can sometimes fail due to lack of maintenance (cleaning and lubrication). If you clean and lubricate the unit when the front wheel is off for tire changes etc., chances are slim you'll ever have trouble with it.
The factory centerstands can bend, and the bolts are subject to loosening. SW-Motech makes a better one (large-diameter pins instead of pivot bolts), and it's cheaper.
The plastic tanks don't fare well in a fall. Crash bars are a must with this bike.
Wind buffeting can be bad at high speeds, depending on the windshield used, and the height of the rider. There is no magic windshield for all people.
The suspension is kind of soft for serious sport riding. But it's great for rough roads. If you want taut suspension, the parts are available.
The charging systems can be kind of weak in older models. Improvements can be made using larger wires and fuses... http://tigertriple.com/forum/index.php/msg,26488
Factory radiator caps can weaken over time, allowing the bike to puke coolant even at normal operating temperatures. For about 7 dollars, a part-store replacement for a '88-'91 Honda Civic is a direct fit.
Some models came from the factory with the coolant overflow hoses reversed. Most bikes have had this repaired by now. Also, the small plastic elbows these tubes fit onto have been known to crack, allowing the bike to lose coolant. Brass elbows can be substituted, available at hardware and home-improvement stores for a couple dollars each.
2005 - 2006 models experience a 'clonking' sound in the forks when hitting bumps. It's merely annoying and doesn't hurt anything, and Triumph has told folks it's merely a type of valve used in forks of those model years.
Some factory front brake rotors were not heat-treated correctly and are susceptable to warping. It's a warranty item if your bike's new enough. EBC replacement rotors are available if you don't want the Triumph parts.
1999 and 2000 models (885 engine) must never be allowed to run with the bike laying on its side. Doing so pumps oil into the airbox. Once the bike is upright and is started, that oil is drawn into the cylinders, cracking pistons and bending connecting rods if too much builds up. If the bike is run for a few seconds on its side, the spark plugs should be removed and the starter spun for several seconds to pump the oil out of the cylinders.
Some owners have experienced charging system failures due to the alternator stator or regulator / rectifier burning out. Replacement Triumph parts are available, however equivalent stators can be found in the Honda VFR-750 and Kawasaki ZX12R. Aftermarket stators and regulator / rectifiers are available from ElectroSport (http://www.electrosport.com/) and Rick's Motorsport Electrics (http://www.ricksmotorsportelectrics.com/).
There have been a few cases of defective head gaskets, allowing coolant to leak to the exterior of the engine case. This usually occurs in cold weather, when the cases and head contract, allowing coolant to seep out. When the engine warms up, and in warmer weather, the gasket seals well enough to stop the seeping. It's mostly just a cosmetic issue, as the coolant doesn't enter the cylinders, but many owners wind up getting it replaced because it isn't right.
In 27,000 miles, my Tiger experienced a warped front rotor (replaced under warranty) and a charging system failure.
If my Tiger were destroyed or stolen tomorrow, I would go right out and buy another.
Thanks for this info. I do not own a Tiger yet. I am looking at either a Girly or a BMW 1150 GS. I would be interested in knowing just how often these problems occur. After spending time on this site as well as on some BMW sites, I am tempted to go by a Honda! So, what are the odds with a low mileage, clean bike?
Thanks
You should expect to have all of the above faults, as they are built in to the design but easy to remedy. Except the last two (charging system and head gasket) and the brake rotors, these come with the luck of the draw.
Edit: I agree with NKL, below. I sold my 1150GS because of the constant repairs required. In contrast, my Tiger requires next to nothing.
Don't be fooled into thinking a Honda will be better, they have their fair share of camchain tensioner, reg/rec problems headlight bulb holders that melt. All bikes will generally have a problem in their lifetime the bike to avoid is the one that has lots of problems built in, and the Tiger isn't one of those. There are plenty of high mileage tigers on here that have had nothing but servicing and worn out parts replaced as you would expect.
My 2005 has now done 22k miles without fault.
Just check it has been serviced and you should be alright, my 05 is used daily and has 35k miles on it. I have had no major problems and my only spends have been tyres, brake pads, the occasional service and a new chain and sprocket set. Overall it has been a very reliable bike so far.
2005 model somewhere about 35k.
no problems other than wear and tear.
The charging and brake system problems described by Stretch are real. However, take a look at the thread devoted to these problems and you can see that they are rectifiable and should not detract from an otherwise great bike.
Of more concern in my view is the poor aerodynamics and the fundamental top heaviness built into every Girly. Some riders don't notice them, some enjoy the other great features of the bike and ride around them, some find acceptable solutions and some find ownership a miserable experience ( a very small minority).
Just make sure you have a really good try before you buy. I'd have another one tomorrow
Thanks for all the help.
I've had 2 955i's now.
The first was a 2004 spoked wheel model. Problems listed as below in 11000 miles
Incompatible disc and pads. First in the UK and was like a warped disc. Basically the discs would warm up, the pads would overheat and fail, then work, fail etc which felt like a pulsing effect. Personally I reckon the discs warped.
TRIUMPH badge fell off one pannier.
That's it. I was even on the original Tourance tyres and never adjusted the chain either.
Current is a 2007
Only done 200 miles so far in the last week (total is 9700) and there is only one niggle. The suspension is lower so the bike stands more upright than the older versions, meaning it can fall off the sidestand if not careful.
Apart from that I can only agree with the original post about wind protection/noise and add that changing headlight lamps is a right pain in the arse.
Fit OSRAM NIGHTRACERS to the headlights, they really do work far better.
I've lost a badge on a pannier as well and that's about all that has gone wrong in four years, fingers crossed. Thought about fitting nightracers. cheers Spud :wink:
My first 885i(after 6 weeks) blew a head gasket and so did I !! and got rid of it and had another new one,that had discs/shocks replaced and just leaked from the head gasket,my 955 broke a female fuel connector in the worsed possible synario,but apart from that it's been fantastic,i've had it 9 years next may.
2000 model with 46,000 miles on the clock. Apart from service items I have replaced a warped disc (rotor) and replaced fuel connections in tank.
Thats it......apart from stuff I trid and failed with :oops:
I've a 2005 Tiger that's just rolled over 56,500 miles and the only real 'problem' mine's had is the wonky fuel guage. That's not super critical if you watch the trip meter. I need to make the voltage fix, but really, I couldn't be happier with this machine.
2001 955i Tiger. 49,200 miles (hope to hit 50k this weekend)
Problems encountered:
-Fuel fitting failed, one week before recall, 900 miles from home in the middle of the Mojave desert in 100+ temps. Triumph bent over backwards to make it good though, so I appreciate that.
-Low charge voltage. I came up with the "Sasquatch Mod" that fixed it.
-Radiator caps last about 2 years, irregardless on miles.
-Rear brake pads wear quick (rider issue, not bike)
-Very constant, but insanely twisted fuel gauge issue that NO ONE has ever seen before. I deal with it because it always comes around.
-Soft intake valves. Some 2001s had this issue. Finally ran out of adjustment and installed a new, low mileage used head (8,000 on head).
-Soft suspension, but I have a guy that fixed that for me. :wink:
-Goes through tires faster than fast. 7k is about all I can get out of a rear.
-PITA filter cleaning procedure.
But I love her. No intentions on anything new any time in the near future. Swallows miles with ease. Goes off pavement without a fuss. Carries a metric boat load of gear and has only failed on the road once. (fuel fitting).
Quote from: "Sasquatch"-Fuel fitting failed, one week before recall, 900 miles from home in the middle of the Mojave desert in 100+ temps. Triumph bent over backwards to make it good though, so I appreciate that.
Out of interst what as the recall,i know Triumph recalled the plastic males,but's it's the females that went belly up on mine like so many other's.
Quote from: "Chris Canning"Quote from: "Sasquatch"-Fuel fitting failed, one week before recall, 900 miles from home in the middle of the Mojave desert in 100+ temps. Triumph bent over backwards to make it good though, so I appreciate that.
Out of interst what as the recall,i know Triumph recalled the plastic males,but's it's the females that went belly up on mine like so many other's.
Correct. My Female side failed. I still have the new Triumph parts in their packages in my drawer. Never installed them. Went with the all metal Team Triumph fittings and after 50k miles, never had an issue.
One major problem, common to all years and possibly incurable.
The Panniers Leak.
Bulletproof. Will need to change the rear wheel bearings in a couple thousand miles, and will need to clean the speedo head as Stretch mentioned, but otherwise great.
I have yet to adjust a valve (had them checked though!) in 28K.
Hi all i have had my bike since 2001 in which i have had 3 faults and also had work done on the recalls.
1. Front brake discs warped and started to crack on the cooling eyelets
2. Charging system, the geny took out the reg/rec, so replaced both and all ok.
3. Fuel connectors on the fuel pump, which i have now replaced with valved metal units that was discussed on this forum and at quarter of the price of triumph
http://tigertriple.com/forum/index.php/topic,5670 (http://tigertriple.com/forum/index.php/topic,5670)
My current milage is 42000 and would like to say i had my valves last checked at 18000 without adjustment and they have never been adjusted and are still ok there is a slight tick from the top.
I use fully synthetic 10w/40 engine oil and change every 4-6000, i Have Iridium plugs, and the engine pulls like a train.
It is the only bike i have ever owned and kept for this length of time and still swear by it, I have ridden Bikes for 25+ years and owned alot of machines and none of them, owned or not, compare to the Mighty, good allround, Tiger, and best of all its a TRIUMPH. what a machine and would recommend to anyone this bike, In fact a Girly friend of mine once borrowed my tiger for a couple of hours last year (2010) she was that impressed she now owns a 2005 silver 955i with 12000 on the clock, so really its the bike that sells itself even with its quirks, not the salesman.
I am only a few months into my 05 and already love her. I do want to explore a better windscreen as I am getting pounded even with the little Vario adjuster. Any suggestions.
Quote from: "Neverlost"I am only a few months into my 05 and already love her. I do want to explore a better windscreen as I am getting pounded even with the little Vario adjuster. Any suggestions.
Sometimes less is more :wink: ,
i tried going higher when i first got my Girly,but found the best solution for me was the Triumph sports screen,i can ride at 80mph in comfort no problem,
a lot depends on your height,it will take a bit of time for you to find the best solution,but you will,
good luck :D
Have a look here,i know its blue and they only post to the EU,but if you want it,pm me and we can sort something out
this is very cheap,just something for you to consider :wink:
http://cgi.ebay.co.uk/Triumph-Tiger-955 ... 2c5ac1a847 (http://cgi.ebay.co.uk/Triumph-Tiger-955i-Sports-Screen-Kit-50-OFF-RRP-/190501201991?pt=UK_Motorcycle_Parts&hash=item2c5ac1a847)
It seems very personal re screens, most people seem to slate the Genuine Triumph Tall screen, I saw a brand new one on ebay and bought it for £30, I think its great and far better than the MRA Vario screen the bike came with, though I may switch back for summer. I bought a sports screen last summer but couldnt get on with it, that and the fact that although the right colour (Lucifer Orange) its not even a close match!!
Quote from: "Neverlost"I am only a few months into my 05 and already love her. I do want to explore a better windscreen as I am getting pounded even with the little Vario adjuster. Any suggestions.
You'll have to give us your vital statistics like height and inside leg measurements because that's what'll determine whether my screen will work for you. As Timbox2 points out it's very a personal thing.
Rather than turning this thread into a screen thread, there must be numerous other threads dedicated to the Girly screen problems that you can search and read.
Neverlost - Not sure what you're running now, but the Palmer brackets and windscreen (3 sizes - ive got medium) works great. Its adjustable over a small range - 3 positions up / down, and 3 back to front. I also had a parabellum windscreen that I used in winter (a bit wider & curved) but it broke on a wind induced tip over (70mph!) in a Maine motel parking lot. CRAP! Anyway - Palmer brackets are a good investment.
Quote from: "Stretch"1999-2006 TIGER FAULTS AND WEAKNESSES
1999-2003 Tigers came from the factory with all-plastic fuel line fittings at the tank, and are known to split, causing gasoline leaks. This was the subject of a factory recall in 2003. 2004 models have improved (partially metal) fittings. All-metal fittings can be had from TeamTriumph... http://www.triumph1.com/tiger.htm (http://www.triumph1.com/tiger.htm) . These items are not needed for (and will not fit) 2005-06 models, as they have a slightly different fuel system.
I just want to clarify this statement. I have a 2005 model and it indeed had the two plastic fittings (male and female) and the metal kit from Team Triumph did work on my bike. Just wanted to through that out there.
Quote from: "fret"One major problem, common to all years and possibly incurable.
The Panniers Leak.
Ah standard ones leak but theirs a quick fix... change them to Alpos Aluminium boxes. Problem solved
Re the panniers, someone posted up once that if the pannier is not overloaded the main source of leakage is the hinges. I silasticed the bolts that attach the hinge to the pannier and it has stopped most of the leakage.
In the OP Stretch pointed out the poor instrument backlighting at twilight. Previously I agreed with him but on this years border run ( 3500miles in four days) I had a revelation.
When you ride at twilight there is a period of aobut 40 minutes, depending on where in the world you live where it is not dark enough to use high beam/spotlights and the natural light is not good enough to see the kamakazi beasties. Surprise surprise this corresponds to the period where the backlighting for the instruments is ineffective.
So when it's hard to read the instruments that means its hard to see what or who wants to throw themselves under your wheels. So slow down or get off the road for a bit. Thanks for the handy design feature Triumph!
Quote from: "GARYSTIGER955i"Hi all i have had my bike since 2001 in which i have had 3 faults and also had work done on the recalls.
1. Front brake discs warped and started to crack on the cooling eyelets
2. Charging system, the geny took out the reg/rec, so replaced both and all ok.
3. Fuel connectors on the fuel pump, which i have now replaced with valved metal units that was discussed on this forum and at quarter of the price of triumph
http://tigertriple.com/forum/index.php/topic,5670 (http://tigertriple.com/forum/index.php/topic,5670)
My current milage is 42000 and would like to say i had my valves last checked at 18000 without adjustment and they have never been adjusted and are still ok there is a slight tick from the top.
I use fully synthetic 10w/40 engine oil and change every 4-6000, i Have Iridium plugs, and the engine pulls like a train.
It is the only bike i have ever owned and kept for this length of time and still swear by it, I have ridden Bikes for 25+ years and owned alot of machines and none of them, owned or not, compare to the Mighty, good allround, Tiger, and best of all its a TRIUMPH. what a machine and would recommend to anyone this bike, In fact a Girly friend of mine once borrowed my tiger for a couple of hours last year (2010) she was that impressed she now owns a 2005 silver 955i with 12000 on the clock, so really its the bike that sells itself even with its quirks, not the salesman.
Update I still love my Tiger even after 11 years of ownership.. I now have 60,000 miles on my Tiger 955i, the tappets are still in good shape and have never been touched, i average 15000 miles on a set of tourance tyres, I still average 60mpg combined, I have replaced the Breather oil seal as oil was entering the airbox, Im still on the above iridium plugs, and have just replaced the original air filter (at 53000 miles) with a K+N unit, I am now on my 3rd stator and 4th Reg/Rec, the 3rd was replaced under warranty from http://www.electrexworld.co.uk/ and I did the RR mod when I changed the Fuel connectors, I am using the upgraded cooler running Mosfet RR. I have had Issues with Powerbronze taller touring screen, so now on standard triumph screen which is still noisey, but have now bought a ceebaileys type2 8+ with winglets in light grey for less than £170 from http://www.woodysimportarium.com which I hope will reduce noise and give more protection in winter riding. I hope this gives you an idea of what to expect of a Tiger if looked after, I didnt mention, but must mention when I first bought the Tiger I did treat her to a bottle of Active8 http://www.activ8lubricants.com/ this is better than slick50, and is a proven product, I have used this stuff in all my bikes and have never had a mechanical problem.. Just a thought. Happy Riding.
Stretch, Thanks for great information! I recently got a 2006 Tiger and was a little concerned about the "clonking' in the front forks. Thought the head bearings needed to be adjusted.
This is a terrific Triumph Tiger specific web site. :eusa_clap
Rod
It may be a while before you hear from Stretch; he was punted off a couple of years back and went 4-wheel. He still pops in occasionally but, being the unparalleled master of all things Girly, he's sorely missed.